The most common reasons why a radiator fan is not working are due to a blown fuse, a bad relay, or a broken wire. It can also be caused by a faulty coolant temp sensor, low coolant level or the fan itself can be damaged.
How do you test a radiator fan on a BMW?
What are the symptoms of a faulty cooling fan switch?
Common signs include engine overheating, the Check Engine Light coming on, and a broken or shorter signal wire.
How can you tell if a fan relay is bad?
One of the first symptoms commonly associated with a bad or failing cooling fan relay is an engine that runs hot or overheats. If you notice that your engine is running at higher temperatures than normal, that may be a sign that the relay is not functioning properly.
Can I drive car without cooling fan?
Yes, you can drive your car without a radiator fan, but you never should. Your vehicle’s cooling system is crucial to its performance, and every time your engine overheats, you cause damage.
What sensor turns on the radiator fan?
On most modern cars, the cooling fan is controlled by the Engine Control Unit (ECU) which gets a signal from the coolant temperature sensor. If it’s not working, the fan won’t turn on when it needs to, which means the engine might overheat.
How do I check if my radiator fan is working?
A simple way to check if the radiator fan is working is to start your engine and turn the air-conditioning system (A/C) to the maximum speed. If the fan is spinning, then it means that the fan motor, fuse, wiring, and relay are all working properly.
When should the radiator fan come on?
Your radiator fan should kick in at about 200 degrees Fahrenheit. If you notice your vehicle is overheating or at the very least running hotter than it normally does, listen for the fan to see if you can hear it.
How do you test a fan relay?
How can you tell if a radiator fan fuse is blown?
How do you test a fan motor?
- Check the power. If you suspect the fan motor is bad, the first thing you should check is the power to the motor and the power to the air conditioning unit.
- Check the windings. Next, check the windings of the fan motor for an open or a short.
- Inspect the capacitor.
Should radiator fan run all time?
It’s not normal for radiator fans to always run, even when the engine’s temperature is high. Continuously running can shorten the lifespan of the radiator fan. For this reason, the configuration of cooling fans allows them to cycle on and off only when the need arises.
How do you check if a relay is working?
Does radiator fan affect AC?
The radiator fan pulls air through the condenser, which removes the heat vapor of the refrigerant inside. If the radiator fan fails, it will affect the AC performance.
How do you test a coolant fan switch?
What to do when cooling fan stops working?
Does the thermostat control the radiator fan?
The thermostat found in the cooling system will control many of the electric fans. When a certain preset temperature has been reached by the car engine, the radiator fan will begin to cool the engine. The fan will turn off eventually if the temperature goes below the preset engine temperature.
How much does it cost to replace a cooling fan?
The average radiator fan replacement cost is typically between $550 and $650. In many cases, the radiator fan will cost around $400 to $450, while the labor adds $150 to $200. However, some vehicles can be more expensive, depending on the design.
What ECU controls the radiator fan?
The engine-ECU
Where is the radiator fan fuse located?
Where is the cooling fan sensor located?
On most vehicles, the coolant temperature sensor (CTS) can be found somewhere near the engine thermostat, which allows it to function optimally. The tip of the CTS is probably located right next to the engine coolant.
How much is a radiator fan repair?
Replacing a radiator fan takes anywhere from 1.5-3 hours, making the average cost of labor between $115-$375. Depending on your vehicle, a new radiator fan assembly could cost anywhere from $100-$600. After all, is said and done, it could cost you between $400-$1,000 to have your radiator fan replaced professionally.
How do I know if my coolant temperature sensor is bad?
- Poor Fuel Economy.
- Irregular Temperature Readings.
- Black Smoke from Your Exhaust.
- Your Engine is Overheating.
- Your Check Engine Light is On.
What are the two fans in my car?
On many vehicles, there may be two fans: a main cooling fan for the radiator, and a second fan for the condenser.